Boiler - Safety Program

Proper preparation in necessary to ensure a safe condition exists for the inspection. When a boiler is to be prepared for internal inspection, the water level should not be lowered from normal operating level until the unit has been cooled down. Cooldown of Boilers is …

Read more

Boiler Inspections: A Complete Guide

Internal inspections of firetube boilers can range from looking into inspection openings with a mirror and flashlight to actually crawling inside when the boiler and access openings are large enough. Any time the inspector's head enters the fireside or waterside of the boiler, the atmosphere must first be checked for oxygen content and the

Read more

Vertical-Tube Boiler

Vertical-Tube Boiler. In some fire-tube boilers, the tubes run vertically, as opposed to the horizontal arrangement in the Scotch boiler. The VERTICAL-TUBE boiler sits in an upright position, as shown in figure 1-3. Therefore, the products of combustion (gases) make a single pass, traveling straight up through the tubes and out the stack.

Read more

Fire Tube Combi Boiler Installation & Service Manual

FIRE TUBE COMBI ™ Fire Tube Combi Boiler Installation & Service Manual Models: 110 - 199 Provides access to all internal components. 24. Ignition / flame sense electrode Used by the control module to detect the presence of burner flame. 25. Flame inspection window The quartz glass window provides a view of the burner surface and flame. 26

Read more

ANNUAL BOILER MAINTENANCE-BEST PRACTICES

It can drop a boiler's efficiency by as much as 12% - 21%. 6. Re-start the equipment and adjust combustion using a calibrated analyzer. A water tube manometer will be necessary to check for proper draft readings. 7. Inspect electrical connection for corrosion. Condensation can cause corrosion on the electrical connections of a boiler.

Read more

Factory owners must ensure the boiler is

9. FIRE-TUBE BOILER EMERGENCIES (a) When the boiler is steaming with water level not visible in the gauge glass, shut off the burner immediate1y. Test the gauge glass or test cocks. If low water level established in the boiler . NEVER. add water into the boiler right away. Locate and rectify the fault, wait until the boiler has cooled down,

Read more

Related Information